Toyota Land Cruiser

FJ60, FJ62 and FJ80 1980-1997 of release

Repair and car operation

Toyota Land Cruiser
+ 1. Maintenance instruction
+ 2. Maintenance
- 3. Engines
   + 3.1. Engines 2F and 3F-E
   + 3.2. Verkhneklapanny engine 1FZ-FE
   + 3.3. Dismantle and major maintenance of the engine
   - 3.4. Engine electric equipment
      3.4.1. Technical characteristics
      3.4.2. Battery
      3.4.3. Power cables
      + 3.4.4. Ignition system
      3.4.5. Ignition coil
      3.4.6. Ignition distributor
      3.4.7. Block of electronic ignition
      3.4.8. Induction sensor
      + 3.4.9. System of a charge of the battery
      3.4.10. Generator
      3.4.11. Generator details
      3.4.12. System of start-up of the engine
      3.4.13. Starter electric motor
      3.4.14. Traction relay of a starter (and/m 1980-87 of release)
+ 4. Systems of cooling, heating
+ 5. Fuel and exhaust systems
+ 6. System of decrease in toxicity
+ 7. Transmission
+ 8. Brake system
+ 9. Suspension brackets and steering
+ 10. Body
+ 11. Electric equipment
+ 12. Electroschemes

3.4.12. System of start-up of the engine

GENERAL INFORMATION

System of start-up of the engine (1980-87)

1. Ampermeter
2. Ignition lock
3. To the ignition coil
4. A conclusion With

5. Conclusion 50
6. Conclusion 30
7. Fusible insert

Units of start-up of the engine on cars after 1993.

1. The blocking switch
2. AM1 FL 1,25 B safety lock

3. Starter
4. AM1 safety lock (50 And)

The system is intended for engine start-up at the expense of rotation of a cranked shaft with necessary speed and consists of the battery, a starter, the traction relay and connecting wires. The traction relay is mounted directly on a starter (see fig. Details of a starter of cars of 1980-87).

Prevention

The drive of a gear wheel of a starter on cars of 1980-87 is provided with the lever connected with a plunzher of the traction relay. Since 1988 on Land Cruiser cars 2 types of starters with a planetary reducer are established. Starters of these types are not subject to repair and change assembled with the traction relay.

On cars from a manual transmission the starter joins only after pressing a coupling pedal. On cars with automatic transmission the starter joins after transfer of the selector to the situation Park or Neutral.

Precautionary measures

At works with units of system of start observe the following precautionary measures.

Inclusion of a starter is allowed for the period of no more than 15 seconds with the subsequent pause not less than 2 minutes.

As the starter is directly connected to the battery, at inept actions, overloads or casual short circuits formation of an arch and fire emergence is possible.

Before the beginning of repair of units of system of start of the engine always disconnect the battery from weight.