Toyota Land Cruiser

FJ60, FJ62 and FJ80 1980-1997 of release

Repair and car operation

Toyota Land Cruiser
+ 1. Maintenance instruction
+ 2. Maintenance
+ 3. Engines
+ 4. Systems of cooling, heating
+ 5. Fuel and exhaust systems
+ 6. System of decrease in toxicity
+ 7. Transmission
+ 8. Brake system
+ 9. Suspension brackets and steering
+ 10. Body
- 11. Electric equipment
   11.1. Search of malfunctions
   11.2. Safety locks
   11.3. Fusible crossing points
   11.4. Breakers
   11.5. Relay
   11.6. Breaker of indexes of turn / alarm system
   11.7. A combination of switches on a steering column
   11.8. Lock of ignition and lock drum
   11.9. Indexes of level of fuel, pressure and oil temperature
   11.10. Guard of devices
   11.11. Screen wiper electric motor
   11.12. Receiver and loudspeakers
   11.13. Aerial
   11.14. Heater of back glass
   11.15. Headlights
   11.16. Case of a halogen headlight
   11.17. Sound signal
   11.18. Replacement of lamps
   11.19. Lateral mirrors with the electric drive
   11.20. System cruise control
   11.21. Window regulator electric drive
   11.22. Electric drive of door locks
   11.23. Safety cushions
+ 12. Electroschemes

11.23. Safety cushions

GENERAL INFORMATION

Safety cushions (System of pneumosafety of SRS) are intended for protection of the driver (and the passenger) on a forward seat in case of collision.

On a part of cars 2 pillows are provided, one of which (from the driver) is mounted in the central part of a wheel, and another – on the right side of the forward panel of salon. The system also includes the block of sensors and the management, mounted on the car center.

THE SAFETY MODULE FROM THE DRIVER

The structure of the module includes the packed pillow and the device forcings (reactor) which is under a pillow and is connected to it an opening through which it is injected gas at receipt of a signal. The signal moves on a cable winded in a flexible spiral round a shaft of a wheel, irrespective of a wheel angle of rotation. The pillow is inflated with the nitrogen which is forming as a result of reaction of an oxide of copper and азида of sodium.

THE SAFETY MODULE FROM THE PASSENGER

The structure of the module located over a box for trifles, includes the device the forcings (reactor), the combined pillow, the reactor and the facing panel. Pillow of the passenger much more than pillow of the driver. External furnish of a cover of a pillow coincides with furnish of the forward panel. In a cover the seam which breaks when forcing gas in a pillow (gas is provided is formed as a result of reaction of an oxide of iron and азида sodium).

SENSOR AND DIAGNOSTICS BLOCK

The block provides a food and safety cushion operation even at the disconnected battery. The block checks a condition of system of safety. The control lamp of system (AIR-BAG lamp) at first lights up and at serviceable system dies away. If the system is faulty, the lamp continues to burn or blink (or the sound signal) is distributed. In this case it is necessary to hand over the car immediately in car-care center for check.

Prevention

To disconnect pneumosafety systems.

The neglect precautionary measures leads to casual disclosure of a pillow and to heavy traumas.

At performance of any works near a steering column or any unit of system it is necessary to disconnect safety cushions. For this purpose execute the following:

  – expose wheels in the provision of driving on a straight line and transfer the ignition key to the situation LOCK;
  – disconnect the battery from weight;
  – start works later not less than 90 seconds, i.e. through time necessary for the category of the condenser.

At manipulations with the pillow container always keep the revetted party of the container in the direction from itself. It is forbidden to put the container the revetted party down. It is forbidden to measure resistance of any unit of system of pneumosafety as pillow operation from an ohmmeter battery is possible.

Before performance of welding works disconnect the socket of a safety cushion of yellow color which is located under a steering column about the socket of a combination of switches (from the driver) or a box for trifles (from the passenger).

It is forbidden to throw out the container with a pillow.