Toyota Land Cruiser

FJ60, FJ62 and FJ80 1980-1997 of release

Repair and car operation

Toyota Land Cruiser
+ 1. Maintenance instruction
+ 2. Maintenance
+ 3. Engines
+ 4. Systems of cooling, heating
+ 5. Fuel and exhaust systems
+ 6. System of decrease in toxicity
+ 7. Transmission
+ 8. Brake system
+ 9. Suspension brackets and steering
+ 10. Body
- 11. Electric equipment
   11.1. Search of malfunctions
   11.2. Safety locks
   11.3. Fusible crossing points
   11.4. Breakers
   11.5. Relay
   11.6. Breaker of indexes of turn / alarm system
   11.7. A combination of switches on a steering column
   11.8. Lock of ignition and lock drum
   11.9. Indexes of level of fuel, pressure and oil temperature
   11.10. Guard of devices
   11.11. Screen wiper electric motor
   11.12. Receiver and loudspeakers
   11.13. Aerial
   11.14. Heater of back glass
   11.15. Headlights
   11.16. Case of a halogen headlight
   11.17. Sound signal
   11.18. Replacement of lamps
   11.19. Lateral mirrors with the electric drive
   11.20. System cruise control
   11.21. Window regulator electric drive
   11.22. Electric drive of door locks
   11.23. Safety cushions
+ 12. Electroschemes

11.5. Relay

GENERAL INFORMATION

On considered cars of the relay are included in chains of such consumers as units of fuel system, a starter, fog lights, a sound signal. Relays are applied to operated inclusion and shutdown of the silnotochny consumer under the influence of an electric signal of low power. Relays are mounted in the uniform block located in a motor compartment, and also in various parts of the car. The relay can be got and checked, the faulty relay is replaced.

Installation of the relay of electric equipment of FJ60 cars

1. Relay of system of ignition
2. Relay of turning on of lighting devices
3. Relay of inclusion of back lamps
4. Relay of the fan of a heater
5. Screen wiper relay
6. Relay of the fan of system of cooling of the engine

7. Breaker of turns
8. Processor of system of decrease in toxicity of exhaust gases
9. Timer of preliminary heating
11. The socket for a portable lamp
12. Processor of seat belts
13. Relay of a control lamp of a charge of the battery
14. Resistor of an alarm lamp

Installation of the relay of electric equipment of FJ62 cars

1. Relay of seat belts
2. Relay of a back heater
3. Relay of a cleaner of a windscreen
4. Breaker
5. Relay of a cleaner of headlights

6. Relay block
7. Combination of devices
8. Tachometer
9. Speedometer
10. Hours

Installation of the relay of electric equipment of FJ80 cars

1. Relay 2 block
2. Battery
3. Fusible crossing point (main, AM1 and AM2)

4. Block of safety locks
5. Relay 1 block

Check

PERFORMANCE ORDER

1. Check with use of the scheme of turning on of the relay gives the most reliable results. If the scheme of inclusion is absent, execute checks taking into account the following data.

2. Pair of conclusions of any relay is connected to the coil providing operation of the relay. Other conclusions become in pairs isolated or disconnected at a coil zapityvaniye.

3. As a rule, distributing of contacts is specified on the relay case.

4. Connect one of conclusions of the coil of the relay to a positive conclusion of the battery through a wire with a thin delay as a safety lock. The second conclusion connect to weight. After connection click should be listened. If click is not present, change polarity of connection (polarity of connection matters on some relays).

5. Check chain existence between relay conclusions according to marking on the case.

6. If results of checks negative, with the relay replace.